This is for general posts and questions concerning only the Voyager XII (1200cc, Four-cylinder) Years 1986 thru 2003.
Moderators: the2knights , Highway Rider
2024 International Rally Reveal
Replies: 1
First post
2024_internal_rally_reveal.mp4
Last post
:woohoo:
1 Replies
39802 Views
Last post by Deep Thoughts
Fri Jun 23, 2023 8:01 am
0 Replies
33450 Views
Last post by Highway Rider
Thu Jun 22, 2023 12:02 pm
Another new owner
Replies: 13
by
BonVoyager »
Wed Aug 03, 2022 12:29 pm
First post
Hi , and thanks for signing me up. I didn't see an intro section so I guess this is the appropriate place to post first time. I just acquired a 99...
Last post
Audio System manuals
13 Replies
484 Views
Last post by triton28
Tue Aug 16, 2022 11:14 pm
New voyager owner
Replies: 11
by
Conrad »
Tue Jul 26, 2022 11:35 pm
First post
Resized_20220726_181638.jpeg
Last post
NGK Iridium spark plugs; Progressive Fork Springs and Progressive Rear Shocks with dual rate springs; OOP voltage meter which tracks battery life;...
11 Replies
548 Views
Last post by SgtSlag
Tue Aug 09, 2022 2:46 am
Carb 4 does not want to fill with fuel
Replies: 5
by
Chris Cochran »
Fri Aug 05, 2022 5:47 pm
First post
Subject: Carb 4 not filling
Last post
When draining carbs 1 thru 3 each carb took me to the count of 25 before the drain stream petered out.
5 Replies
204 Views
Last post by Nails
Mon Aug 08, 2022 11:07 pm
3d making obsolete parts, my project
Replies: 15
by
Avidrider62 »
Sun Mar 14, 2021 1:31 pm
First post
I'm working on making obsolete parts. Software, learning curve, 3d printer are in my works. I'd have to back engineering the products. I have the...
Last post
Gene ekap1200 makes stainless steel replacements. I just bolted my trunk down without spacers. So it doesn't slide, so what LOL
15 Replies
1090 Views
Last post by GrandpaDenny
Sat Aug 06, 2022 9:29 am
Cylinders 2 and 3 do not appear to be firing
Replies: 14
by
ComputerGeek59 »
Mon Aug 01, 2022 7:52 pm
First post
I have a 1998 Voyager XII and it had been working great until I tried to start it after the winter. It did not want to start but I eventually got it...
Last post
Just a thought, but if you pull plug 1 and 2, ground them and spin it over to check for spark, you can always switch the plugs between wires and try...
14 Replies
349 Views
Last post by ComputerGeek59
Thu Aug 04, 2022 2:42 pm
Removing float bowls while carbs installed?
Replies: 4
by
Heavy Armor »
Mon Jul 18, 2022 7:04 pm
First post
I sure as heck don't wanna pull off these new carbs again, but they are leaking like a sieve around the float bowl screws (at least that seems to be...
Last post
Sounds like you need to go back through the carbs to verify they're right. Since they're off, I'd definitely suggest looking beyond the float-bowl...
4 Replies
243 Views
Last post by Nails
Mon Aug 01, 2022 1:03 pm
forever bikeless in San Jose..…..
Replies: 9
by
cranky »
Thu Jul 21, 2022 7:52 pm
First post
well my last scoot went to recycler heaven and that’s all, I just can’t take another beating like I’ve had..….. 4 wheels from now on..…. I loved my...
Last post
Maybe a Polaris Slingshot would be a good in between. 😄
9 Replies
342 Views
Last post by Heavy Armor
Mon Aug 01, 2022 4:24 am
Ìn Search of Blue '95 Lower Left Side Fairing Deflector
Replies: 13
by
DocSnowFox »
Mon Jul 20, 2020 3:52 am
First post
ISO/Ìn Search of Blue '95 Lower Left Side Fairing Deflector.
Last post
VoyKimmer,
13 Replies
729 Views
Last post by DocSnowFox
Sat Jul 30, 2022 9:36 pm
Radio antenna
Replies: 10
by
mayhem8 »
Mon Jul 25, 2022 12:01 pm
First post
Does anyone know offhand if the antenna cable goes to the radio as one cable, or is it 2 pieces. If the latter, where is the joining connector (i.e....
Last post
GrandpaDenny,
10 Replies
388 Views
Last post by mayhem8
Sat Jul 30, 2022 1:33 pm
Final gear drive assembly housing
Replies: 5
by
Chris Cochran »
Sun Jul 24, 2022 1:11 am
First post
Ok, with my wheel off this thing is greasy dirty, big time. It's difficult to see from this specific picture but there are eight bolts visible....
Last post
Ok, got the final drive off, drained, and eventually cleaned decent enough. Splines lubed. Got the swing arm off, pulled the bearings and greased...
5 Replies
233 Views
Last post by cushman eagle
Mon Jul 25, 2022 12:45 am
Power to headlight went kaput!
Replies: 20
by
Heavy Armor »
Tue May 31, 2022 2:19 pm
First post
So my bike has developed an intermittent problem of losing all power to the headlight. It's not the bulb, dimmer switch doesn't seem to have any...
Last post
You may want to just cut the 10 pin connector out and solder all of them to prevent other electrical issues and just get it over with. I did this on...
20 Replies
719 Views
Last post by VoyKimmer
Sat Jul 23, 2022 11:03 pm
Such a FRUSTRATING machine!
Replies: 7
by
Chris Cochran »
Thu Jul 14, 2022 10:55 pm
First post
I've had mine since May, and in that short time period I have learned a well-earned truth about the Voyager XII: It is FRUSTRATING to work on. I've...
Last post
The funny thing is that my initial project was to rebuild the carbs.....
7 Replies
348 Views
Last post by Heavy Armor
Tue Jul 19, 2022 6:40 pm
Throttle cable junction box repair
Replies: 25
by
Deep Thoughts »
Tue Jul 12, 2022 3:59 pm
First post
Hello Gentlemen.
Last post
The throttle cable junction box is one item I have never opened as I don't do well with coiled spring activated rotating discs of any kind. Even a...
25 Replies
715 Views
Last post by triton28
Tue Jul 19, 2022 9:30 am
Gertrude Gets A New Air Cleaner
Replies: 3
by
GrandpaDenny »
Mon Mar 07, 2022 3:41 am
First post
K&N filter for I think '82-85 Camaro. No trimming required, it snapped right in. I filled in the gaps with Permatex Ultra Black. I discovered a few...
Last post
Eight lights? Eight lights? Between here and the expressway to work, a whole mile and a half, there are seven traffic lights and seven stop signs.
3 Replies
280 Views
Last post by GrandpaDenny
Tue Jul 19, 2022 2:38 am
Windshield
Replies: 4
by
My99xii »
Thu Jul 07, 2022 2:36 pm
First post
Does anyone know where I can get a new windshield for my 99 voyager? Preferably around 10 and tinted. Also if anyone knows a good website for parts...
Last post
Thanks for all the help I appreciate it!
4 Replies
290 Views
Last post by My99xii
Sat Jul 16, 2022 7:26 pm
Any quick tips on intake duct spring?
Replies: 7
by
Heavy Armor »
Mon Jul 11, 2022 2:54 am
First post
I'm >this< close to having my carbs back on and sunnuva%^$&!, one of those stinkin' duct springs, the ones that are a PITA to roll back on, popped...
Last post
Oh fergawdsakes. :roll:
7 Replies
305 Views
Last post by Nails
Wed Jul 13, 2022 12:20 am
Is there a difference in ride quality?
Replies: 9
by
Chris Cochran »
Mon May 16, 2022 3:22 pm
First post
Ok, there's the 86's and the 87's+ years. The 86's have smaller diameter front forks with the 87's and up having larger, heavier duty forks. For...
Last post
Yea, me too lol. I didn't realize I posted it twice, my bad.
9 Replies
446 Views
Last post by Doug
Mon Jul 11, 2022 9:19 pm
Flush Hydraulic Brake Line
Replies: 2
by
Dragon Lord »
Sun Jul 10, 2022 4:31 pm
First post
2000 Voyager XII Trike (Kit). Clutch has quit working.
Last post
It may also be that the return port in the master cylinder is plugged,try opening the the bleed on the slave cylinder behind the chrome left engine...
2 Replies
160 Views
Last post by cushman eagle
Sun Jul 10, 2022 6:37 pm
Blind spot and or extra or different mirror options?
Replies: 4
by
Bonnie and Clyde »
Sun Jul 03, 2022 3:59 pm
First post
I find myself sometimes wishing the stock mirrors were bigger. They work and are adequate but could use some help. They dont seem big enough to put a...
Last post
So there is no classified add with Kevin listed how do I contact him?
4 Replies
246 Views
Last post by Bonnie and Clyde
Tue Jul 05, 2022 2:29 pm
Threaded Holes near Brake and Clutch Levers
Replies: 5
by
Dtown »
Thu Jun 30, 2022 4:33 pm
First post
Hi, I'm an owner of a 2003 Voyager X!! and just noticed that there are threaded holes (covered by a cap) near the Clutch and Brake levers.
Last post
Thanks! I'll reach out to Carl! He's helped me before and a great resource!
5 Replies
260 Views
Last post by Dtown
Tue Jul 05, 2022 1:16 pm
Another oil change question.
Replies: 3
by
Rich in New Jersey »
Sun Jul 03, 2022 11:39 pm
First post
Alright I changed the oil again on my 91 with Rotella 15w40 with filter and put 3qts 22oz back in and nothing is showing in the sight glass, no...
Last post
Thanks for the reply. I've changed the oil many times over the years, the bike is level and sat all night yet nothing shows. I haven't ridden it yet...
3 Replies
221 Views
Last post by Rich in New Jersey
Mon Jul 04, 2022 1:24 am
Gertrude Gets a New Rear Tire
Replies: 8
by
GrandpaDenny »
Sun Jun 19, 2022 3:04 am
First post
Finally got the new Shinko 777 installed today. 14,000 miles on the old Elite 4 and it was balder than I am. Immediate impressions:
Last post
Finally remembered to measure my tread depth. I put the new shoes on roughly 2100 miles ago and measured around 3/16 on the front and 1/4 on the...
8 Replies
348 Views
Last post by Sidehopper
Fri Jul 01, 2022 3:19 am
New voyager owner with issues...
Replies: 9
by
Chips900s »
Wed Jun 29, 2022 1:13 am
First post
Hi all! Looks like a great site with a wealth of information! I have a few questions I didn’t easily find searching and was wondering if anyone could...
Last post
I saw that it was close to me in NH next year! I’ll keep it in mind!
9 Replies
383 Views
Last post by Chips900s
Thu Jun 30, 2022 5:36 pm
Tires and Gas Mileage
Replies: 17
by
Sidehopper »
Fri Aug 20, 2021 6:53 pm
First post
As long as I can trust that the GPS apps on my phone are accurate, it appears that moving to Shinko 777 HD tires has corrected my speedometer...
Last post
That's interesting about adding a vacuum leak helping the bike run better. I had a '76 (IIRC) Datsun 260Z (IIRC) that I think had a bad MAP (or was...
17 Replies
1284 Views
Last post by GrandpaDenny
Wed Jun 29, 2022 10:24 pm
Two questions: 1) Radio 2) Carb rebuild kits
Replies: 3
by
Chris Cochran »
Sat Jun 25, 2022 7:02 pm
First post
1) Radio: Is there a control somewhere on it that allows me to change volume on the left or right speaker? If so, I haven't found it yet. My right...
Last post
Is there a Voyager tribe preferred source for carb rebuild kits?
3 Replies
185 Views
Last post by Nails
Mon Jun 27, 2022 11:40 pm
Forum permissions
You cannot post new topics in this forumcannot reply to topics in this forumcannot edit your posts in this forumcannot delete your posts in this forumcannot post attachments in this forum
Forum permissions
Legend
Unread posts Unread postsUnread posts [ Popular ] Unread posts [ Popular ]Unread posts [ Locked ] Unread posts [ Locked ]
No unread posts No unread postsNo unread posts [ Popular ] No unread posts [ Popular ]No unread posts [ Locked ] No unread posts [ Locked ]
Announce AnnouncementSticky StickyMoved topic Moved topic
You cannot post new topics in this forumcannot reply to topics in this forumcannot edit your posts in this forumcannot delete your posts in this forumcannot post attachments in this forum
